科朗叉车crown-sp3400-demo-servicemanual维修操作说明书手册

SAFETYGENERAL SAFETY INSTRUCTIONSa▣wGeneral Safety InstructionsDo not allow oils to penetrate the ground or thedrain system.Used oil must be recycled correctly.Oil filters and dehumidifying inserts must beMaintenance and Repair Instruc-treated as special waste.Observe the local author-tionsity regulations.Danger!Immediately neutralize and thoroughly rinse anyObserve the safety instructions in thespilled battery fuid.maintenance manual and the truck op-erator manual.Keep the truck clean.This will facilitate tracingloose or faulty componentsFailure to do so could result in seriousor even fatal injuries to maintenanceMaintain the legibility of the data capacity plate andand other personnel.data plate,waming and instruction decals.Motorised trucks can become hazardous if mainte-Truck modifications and additions may only be per-nance and servicing work are neglected.For this rea-formed with Crown's prior written approval.son maintenance and inspections must be performedat sufficiently short intervals.There must be suitablyThe reliability,safety and suitability of Crowntrained personnel and proper guidelines at your placeof work.trucks can only be ensured by using original Crownparts.Maintenance and RepairBefore Parking the TruckAlways carry out work in accordance with the testBrake until the truck comes to restand maintenance schedule enclosed in thesemaintenance instructions and any applicable ser-vice bulletins.Lower the fork carriage fully.Only qualified and authorized personnel may carryApply the parking brake.out work on the truck.Switch off the truck and remove the key.Keep fire protection equipment at hand and do notuse a naked flame to check fluid levels or to test forWhen parking on a slope or incline always chockleaks.all wheels.Use groundwater neutral,non-flammable solventsBefore Working on the Truckfor cleaning.Always perform cleaning work over anoil separator.Protect the electrical system againstdamp.Jack up the truck so that the drive wheel is clear ofthe ground.Apply the Emergency Disconnect andKeep the work place and battery charging stationdisconnect the battery.clean,dry and well ventilated.MA-0000SP 3400 04/2006.Printed in Gemmany